Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Factory Modifications
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- 669R - 03/01/90
- Tool - Power Diagnotic Kit Components Available
- Closed Service Actions - No Longer Warrantied
- PDU - Software Issue PDU1025
- VIN and Certification Plates/Labels - Location/Replace
- Vehicle - Reacquired Limited Warranty Coverage
- Vehicle - Green Tibbe Key Problems
- Hydraulic System - Operation and Component Functions
- TSB # 1818, Dated 1/91
- Tools - Introduction of Tool Board Overlay Kit
- Service Literature - Availability
- Emission - Parts Return Procedures
- Repair Manual - Ordering Information
- JDS - Software Issue 4040 General Usage Rules
- Tools - Required List S34B
- JDS - Introduction of 4050 Subsection, Supplement Pages
- Wiring Diagrams - Correct Source Information
- Current Draw (Quiescent Drain) - Testing
- VIN and Certification Labels - Replacement
- JDS - Software Issue 4040 System Communications
- Fuse - Fail Warning Affected Fuse Box
- Fuses - Blown, Fail to Illuminate Warning
- Instrument Pack - Buzz Noise
- Odometer - Will Display 48560
- A/C Blower Motor - Noisy
- A/C - Switch Revised
- Radio - Failure
- A/C Drain Case - Sealing Modification
- A/C Condensate Drains - Blocked
- A/C Condenser - Revised
- Tool - A/C Compressor Seal Remove/Replace
- A/C Defrost Flap - Interference Distortion of Duct
- Climate Control System Instability
- R134a Retrofit Kits - Available
- Tool - Freon Recovery System
- Tool - A/C Drain Holes
- R-134a Retrofit Kits - Available
- A/C Control Panel - Intermittently Inoperative
- AC Control Panel - Diagnostic Procedure
- A/C Control Panel - Malfunctions
- A/C Sensor - Revised Design
- Steering Column Lock - Replace
- Power Steering - Lack of Power Assistance
- Tools - P/S Pump Drive Dog Removing and Replacing
- Filler Neck and Cap Design - Revised
- P/S Rack - Unnecessary Replacement Due to Noise
- A/T - MIL ON, Goes Into Limp Mode
- PDU - Vibration Analyzer
- Engine - Nuts and Bolts Usage Information
- Engine - Poor Idle Quality
- PDU Software - Now Compatible With JTP 627/3
- Water Pump - Coolant Leakage
- Cooling System - Antifreeze Leaks
- Cooling System - Preventing Antifreeze Leaks
- Batteries - Maintenance and Testing
- Batteries - Maintenance and Testing Procedure
- Batteries - Discharge Due to Frequent Short Trips
- Battery - After Frequent Short Discharge
- Battery Isolation Switch Kit - Installation and Use
- Battery - Service Procedures
- Battery - Specification Card
- Battery - Test Procedure for No Start
- Fuel Pump - Noise/Chattering/Engine Stalling
- Trip Computer - Innacurate Fuel Consumption Readings
- Ignition System - Spark Plug Corona Stain
- Tool - Rear Strut Valve Block, Relief Vavle R and R
- Ride Leveling Strut - Replacement Information
- Ride Level Struts - Stay at Maximum Height
- Ride Leveling Struts - Faulty Operation
- Rear Struts - Installation Procedure
- Tool - Proper Use of Tool JD15 For Rear Hub and Spacer
- Hubs, Spacers and Shims - Revised
- Tool - JD189 Distributor Body/Rotor Arm Set Position
- Cylinder Head Rear Cover - Coolant/Oil Leaks
- Generator Bracket Bolts - Leaking Oil
- Engine Oil Sump - Install to Prevent Drive Plate Cracks
- Oil Sump - Pressure Relief Valve Access Plug Deleted
- Oil Pump - Use Loctite 501 to Seal Backing Plate
- Install Valve Guide Seals
- Water Pump and Center Gasket - Revised
- Water Pump Revised
- Tool - Coolant System Pressure Test Adaptor
- A/C Receiver Dryer - Service Precautions
- Upper Chain Guide Bolts - Apply Locking Compound
- Front Dampers - Individual/Pair Replacement
- Rear Shock Absorbers Leaking
- Wheel Alignment - Tire Wear/Handling Problems
- Tires - Vibrations, Flat Spotting
- Tires - Pirelli P5 Replaced by P4000 Super Touring Tire
- Door Locks (Tibbe Style) - Repair/Replacement
- Door Sill Locking Button Bezel - Revised
- Door - Front Inner Waist Seal Wind Noise
- Propshaft - Vibration
- Propshaft - Vibration at 30-50 MPH
- A/T - Front Pump/Intermediate Plate Failure
- Fuel Injector - Identification
- Check Engine Light Activates, Fuel Fail Code Set
- ECU - Unnecessary Replacement Due to DTC 29
- EGR Pipe Seal - Hard Starting/Hesitation DTCs 26, 44
- ECU - Unnecessary Replacement
- DTC 44 - Diagnosing Oxygen Sensor
- Front Hub End Float - New Specification and Adjustment
- ABS Multiplugs - Checking
- Recall 89V235000: Rear Caliper Bolt Breakage
- ABS - Procedure If Harness Connectors Become Loose
- Distributor Cap - Revised
- Dashboard Area - Knocking Noise at Idle
- Fuel Tank - Filler Cap Area Filled with Water
- Throttle Valve - Adjustment Guideline
- Engine - Poor Running in Wet or Hot Weather Conditions
- JDS - Carbon Canister Error
- EMS - Code 89 Purge Valve Circuit Diagram Correction
- A/T - Poor Shift Quality
- MIL ON - A/T in Limp Home Mode
- Antenna Mast - Cleaning and Replacement
- Power Antenna Mast - Poor Operation
- Cruise Control - Intermittent or Non Operational
- Radio - Reception Information
- Passive Restraint - Motor Winch Lock Up
- Crankshaft Bearings - Revised
- Main Bearing Cap Bolts - Reuse Twice During Repair
- Oil Pressure Transmitter - Replacement Tips
- Cylinder Head Casting, Gasket - Revised
- Cylinder Head Gasket Edge - Coolant Seepage
- Head Gasket - Improved
- Engine - Knock Noise
- ABS Combined Pressure Warning Switch - Replacement
- Hydraulic System - Pressure Test Revised
- Hydraulic and Ride Levelling - Technical Guide
- Front Suspension - Calculating Pull Index
- Hydraulic System - Operation, Component Functions
- Paint - Scratches, Swirl Marks, Other Surface Damage
- CD Changer - Improper Operation and Diagnostic Procedure
- CD Player - Skip
- Alarm System - Fault Diagnosis
- EGR Vacuum Hose - Incorrectly Routed
- MIL ON - DTCs 29 or 69 With No System Fault
- Check Engine Light - Reporting and Erasing DTCs
- Tool - Fuel Injection Tester
- JDS - Software Reference Guide
- PDU - New Software Update
- PDU - Software Update
- PDU - Software Updates
- PDU - Software 1000 Error Requesting Start Engine
- Washer Fluid Reservoir - Revised to 7 Liter
- Washer Fluid Reservoir - Revised
- Washer Additive Quantities
- Trunk - Water Ingress
- Door Mounted Mirrors - Wind Noise
- Windshield Wiper - Smearing
- Windshield - Replacement Precautions
- Outer Waist Seal Finisher Clip - Revised
- Cooling System - Revised Engine Coolant
- Coolant Header Tank Cap Seal - Leak
- Valve Spring - Revised
- A/T - Gear Selector Cable Check/Adjust Procedure
- A/T - ZF and GM 400 Repair Reference
- A/T - Stalls Engine When Engaging R or D
- A/T - Internal Failure at High Engine Speeds in P or N
- A/T - Harsh 3 to 4 Upshifts or Slip/Judder Engaging R
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - Button Fails to Operate Auto Changer
- Engine - Rough Idle In Drive
- Alternator Drive Belt - Tension Adjustment
- Engine - Stalls At Idle
- Climate Control Panel Assembly - Vibrations
- Oil Pan Drain Plug - Revised Torque Specification
- PAS/Ride Levelling - Adding PS Fluid by Mistake
- A/C ECU, Water Temp Switch - Matched Pairs ID
- Suspension - Alignment Specifications
- Driveline - Vibration Diagnostics and Repair
- Convertible Top/Interior Trim - Cleaning Recommendations
- Passive Belt - llegal to Disconnect
- Motorized Automatic Diagonal Seat Belts
- Recall 93V179000: Passive Restraint System Defect
- MIL ON - A/T in Limp Home Mode After Rain/Car Wash
- Wood Veneer Panels - Repair Process
- Underscuttle - Mounting Revision
- Wood Veneer Repair Program
- Interior Trim - KRYTOX(R) Liquid Applications
- Glass - Bonding Procedures and Materials
- Brake Fluid - Replacement Schedule
- Rear Subframe - Knocking Noise
- Solenoid Valve Block - Component Replacement
- Rear Suspension - Replacing Relief Valve
- Ride Level Sensor - Revised
- Ride Height Sensor - New Modification Procedure
- Rear Suspension - Knock or Sag
- Ride/Level Control - Misdiagnosis of Faults
- Engine - Conditions for Re-Using Cylinder Head Bolts
- Hydraulic System - Valve Block Leak
- ABS Valve Block - Replacement/Repair Kit
- Blue `Hella' Relay - Diagnosis
- Tool - Fuel Pressure Tester Adapter
- Interior - Approved Cleaning Products
- Body - Windshield Damage Diagnostic Guide
- Engine Controls - Removal of Seized Oxygen (O2) Sensors